suzuki intruder wont start

Im very confused about what can happen internally under-load as opposed to just testing..OHMs and AC voltagenot under-load.in gear..bike weight and rider weight. Make sure you did not reverse the new spark plug wires. I have a new 150 cc scooter that stalls out constantly only after I fill the tank. Thank you. We will be able to dig deeper into troubleshooting and faster through these channels than we can in these comments. Hello. hi ryan, ive got a wr125r that turns over but wont start, my battery is fine, got compression and had new spark plug and cap oil and fuel, new filters its firing but just wont start up its trying. 320-358-3409 or by email at techsupport@denniskirk.com. I do not know very much about bikes/engines etc. Once the bike fires on the starting fluid, it will usually help draw the gas through the fuel system. Still scratching my headunfortunately. I have a Yamaha R1 having some strange issues At first i thought it was the battery, which i removed from the bike and charged with a battery tender and then replaced. probably a rookie error. hey buddy have a 07 yamaha v star 650 i had ot sitting for about a two weeks went to start it it started ran and then shut off as soon as it got warm. A better fuel pump is on the way. This will prevent the flow of fuel and therefore your bike will not be able to start. Has new air filter. Is there even gas in the tank? Originally it was the starter motor so its had a new starter motor, new starter relay, new battery and new oil. Soon as i back off throttle it rides fine. I replaced the transistors on the spark unit. Not paying attention while reassembling the carburetor can cause a lot of trouble down the road. I have just been givin a motorbike 750 cc wont start has spark and fuel. still wont fire. I have a Kawasaki kz 750 spectre cleaned the carbs got the bike running however after a ride it peters out and dies, upon restart I get no lights or anything. Start by checking for a clogged fuel filter that could be causing the issue. Ive tried with choke on and off. Hi my name is dean I have a yamaha yzf r1 bikes bean running fine till this afternoon it lost power got home switched off then got a bubbling noise from engine tryed to start her again wouldnt start a rotten smell of fuel could you point me in right direction or tell me what could be wrong?? Contact us:speedyautocc@outlook.com Can u gide me please. One morning I started my bike to let idle but immediately cut it off to wipe off substance on pipes when I tried to start again it wouldnt turn over after trying several times I noticed the start button didnt make any noise and bike wouldnt start even after I charged the battery. Bought bike new, only has 10,000 miles on it and has never been stored outside. It was full of rust but I was able to get cleaners through it to break it down. Bike does turn over. After a jump start, ran great and for few next days. 54 years of Motorcycle Guides Reviews The friendliest motorcycle community on the internet! Just had it tuned up and all the junk cleaned out for sitting for almost a year.everything was great for about a week the my bike just stopped working. My guess would be that a completely full tank is blocking off the vent tube. It has been charged adequately. But had no problem for 3 days until now. But I can roll start it. Do you have a lithium battery installed on the motorcycle? Did you manage to get your intruder back up and running? Fired up but died while warming up 5 min later never came back.im stumped. Plugs are getting fire. I have an 02 gaze 1000 that would start fine. Then let the carb dry. Have, spark (strong now) fuel (cleanno gunkgas tank was thoroughly flushed), in-line filter, good carbs, new coils, swithced out CDI, caps, wires, plugs, etc.but still only have 1/2 a bike. Bad battery connection? What could be the problem?? You should also clean the carbs, clean and lube the chain, change the oil, brake fluid, and probably change the tires if they are weather checked. I have a 2000 yamaha vstar 650 classic. Also the Oil pressure light goes out when I crank it, but no start. New air filter in the stock airbox. The most common culprit is the float. Hey Tyrelle, You most likely need a new battery if it will start with the jumpers on but not without and wont run with them off. Hi I just purchased a 1999 honda cbr600. It died while driving it just shut off. I have a 2005 Kawasaki ninja 250. Motorcycle Repair: Suzuki intruder wont start, intruder 250, eric gorr. I want to sell it. Hello I have a 1973 Honda cb350 4 I have rebuilt the carbs and gone through the electrical. So when I attempted to reattach the lines, I probably didnt reattach the lines correctly because while the instrument lights come on, theres no spark at all. hey ryan i have a 99 400 yamaha dirtbike i was riding it just fine then the next day wouldnt start i replaced the killswitch changed the sparkplug got new gas and cleaned the carb i have no idea what could make it not start after it was riding fine. by NorthernPete Fri Oct 18, 2013 5:40 pm, #4 Still have to ohm check mine, It doesnt look like we carry an exact fit stator for your bike. What else could be the problem.? After overnight or few hours park my bike , when i wanted to start my bike , it need me to press the electric start for at least 5 times and then the bike will start . Cycle wont climb above 8000 rpm in 1st, 2nd.feelslike it just isnt getting enough fuel at 6000-6500 rpms in 3rd, 4th. Please help. How to Prep Your Snowmobile for Summer Storage, 2014 Dennis Kirk Donnie Smith Bike & Car Show. Great articleso my issue is a little weird. He drained oil & gas, cleaned it and it was running perfect. You can take the float and the other carb pieces off and soak them in a cleaner. I am a bot, and this action was performed automatically. Your carburetor has a very important job to perform and if things are blocking it from doing its job, your bike will not run. I killed the power, and now the transmission wont shift (except 1st and neutral), the bike wont start, and the rear tire/break is still locked. Make sure that you reassemble everything properly. I have a gsxr 750 k1.Bike was standing for 2months. turns over fine but doesnt fire up, i check ignition resistor it was burnt-out so i replace and resolder a 100ohms resistor, also i replace ignition coil,sparkplugs ,pickups,stator,rectifier,battery main wire harness,junktionbox. Ive emptied all carbeurators and let them fill up again still no luck. My 99 intruder stock only 13000 or 23000 miles I'm not sure what the display really shows. Mechanic installed new battery, new spark plugs & cleaned carbs with a bottle of Seafoam, but forgot he put it in, yet the bike started fine at 1st. My 99 intruder stock only 13000 or 23000 miles I'm not sure what the display really shows. I havent been able to start it again since then. If you cannot see any gunk in any of them, then you did a good job. It stumbles to 115 and no matter how much throttle i give it its not going any faster. Checked and cleaned every thing.engine getting gas. Hi Keith, I would definitely start by cleaning the carbs. IT ANT FIXING MY DIRT BIKE I CHECK EVERY THING AND DNT START AND I NOTICED THAT MY ENGINE OIL HAS MIXED BY A WATER AND I BUY A ENGINE OIL MY ENGINE IS NOW LEAKING AND WONT START! Also be sure that the float is working properly. Make sure that your spark plug is actually connected. Just as satisfying is the deep rumble from the reverse taper . )what to look for. I have a 1999 Heritage Softail that wont start. Leak down test.?? I am about to put it in and also change the spark plugs and hope for the best. Than I open the engine only few to get out that part.I was succeed. 2003 HD FLHTCUI bike ran fine . Any direction will be greatly appreciated! It won t start when hot but runs fine otherwise. High. Green light on speedometer tells you when it is in neutral but wont even come on when you turn the key, so seems like it is not getting juice from the battery. My brike died on me.it want started. Advice? Next, you will need a good cleaner that is safe to be used with plastics and rubbers. Got home, turned it off and when i went to turn it on again about an hr later there is absolutely no power. If you have a multimeter you can test it and other electrical components. Any help? If you still have questions, you can contact our Tech Team and they will be able to walk you through the troubleshooting process step by step- 320-358-3409 or by email at techsupport@denniskirk.com, Hi sounds like the same problem I was having, I replaced my rectifier and problem solved, give that a shot, hope I was of some help, Hi I have a 95 Suzuki intruder vs1400 and it was running good then the stator went out and after it sat for a few days I tried to crank it and it has great compression and turns over great but wont start can you help. The next thing that you will want to check is for spark. I tested my stator as per your technical supports suggestion. You most likely just need to reprime it. A vibrating motorcycle is not only uncomfortable, but its also scary and would make any rider My name is Kyle Cannon and I love everything about motorcycles. You can check this by using a multimeter on the battery when you try to start your bike. If so any advice would be helpful! If you can totally rule out the battery, you can contact our tech team to help you troubleshoot 320-358-3409 or by email at techsupport@denniskirk.com or you can check out this article- https://www.denniskirk.com/learn/how-to-diagnose-motorcycle. Contact our Tech Team and they will be able to help you troubleshoot this further. I have a 1982 Honda CM 250 C and it will not run. If you do not see anything apparent and obvious, then you may need to remove your carb again and make sure everything got put back together properly. Please contact the moderators of this subreddit if you have any questions or concerns. Ive been fiddling with it for most of the winter months. The battery shows good voltage and is brand new. Earlier in the processyes.with bad rubber and worn seas. Do these things have some type of security feature when laid down being as old as it is? have to give it full gas to get it to start . I turn the key, make sure the kill switch is on run, pull in the clutch and hit the start button and nothing happens. Hi Michelle, if you have access to another battery, I would try that first. The bike starts fine in the morning and after work. Even on 3 cylinder. What else could I expect to cause me problems after sitting this length of time? HELP !!!!!!! It will start up if I crank on it for a minute and find the right spot in the throttle, then itll only run as long as I hold the throttle half open and it runs at 6000 rpms. You can call them at 320-358-3409 or by email at techsupport@denniskirk.com. If I see/feel any bump in the powerband.after installing the 105s, Ill know thats the right direction to turn. Did a leak down test.,,.. good there too. You might want to save testing for compression until its the only thing left to troubleshoot. It will take a minute before the necessary vacuum pull has formed again and fuel is flowing through the carb. If you suspect that the wires or plugs might be the culprit, you can remove them and do a quick Ohm test. Brand new battery as well. Ryan, Also check to make sure the engine has sufficient compression to run. Secondly, you will want to make sure that you do not have any air leaks. Please time Running out. but we notice the light on parking plug is not much. Apr 21, 2014 2001 Suzuki VS 1400 Intruder. 320-358-3409 or by email at techsupport@denniskirk.com, I have a 07 Honda VTX1800t. Hey Madalina. Check your fuses first. Can they fail..under load? When my friend and I started taking things apart, I saw that there was a long hairline crack on the cylinder head. It wants to turn over but cant.thank you. Below are some of the basic steps that you can take to get your motorcycle started and back on the road again. If you are not careful, you may accidentally put the float back together upside down after cleaning. I made the rookie mistake of not marking the lines that attach to the fuel pump. But this time bike didnt startup. No horn, blinkers, nothing. Start by checking the simple and easy things. Honda xr125L. I turned it off then on again and there is no electricity going through the bike even though it has a brand new battery with a full charge. The bike started for the first time after winter storage, I rode it for about 5 miles. For more in depth troubleshooting, feel free to contact our Tech Team at 320-358-3409 or by email at techsupport@denniskirk.com, When I started engine it stopped 5 seconds later and when tried again it didn t start One day i was starting the bike to go to work and the bike started just fine, i was holding the throttle a little to warm it up and when i released it, my engine died along with all my electricity while my key was still in the on position. Feel free to contact our tech support at 320-358-3409 or by email at techsupport@denniskirk.com. I have a 2003 yamaha v star 650. I would look a little more into the neutral . Put a new fuel filter in and now it wont start. Hey Ryan I stumbled on your site and this is a long shot but here goes. Home; Church. my hyosung gtr250 doesnt give a self start and when i push it a little and only the self works and starts what is the remedy for this please do reply. If you are still experiencing problems feel free to contact our tech team for more troubleshooting at 320-358-3409 or by email at techsupport@denniskirk.com. Hi! 02:07 - Source: CNN. Hello! Bot a charger and hooked it up. Doesnt seem to be vac-leaking anywhere that I can detect. I have had this bike to 165 many times with no problems. Help! You can try a new spark plug, the spark may not be strong enough. In most cases like this it will be a junk battery. Stock is 107.5 on a Yamaha FZ 600 (86-88).waiting on some 105s. Problem of no power after 9000 rpms (in Neutral) and under 8500 in 1st.under 8000 in 2nd and struggling to reach even 6500 rpms in 3rd. Hi, this could be any number of things. Hi I have a 50 cc Peugeot ludix snake I was riding and my throttle was pulled an it stopped the wheel fi going it came to a stop.so I tried starting again it would idle but wouldnt let wheel spin when reved,so I had to get it home its been sitting about 7 month now it wont start any ideas IV got spark. Hey Brad, the first thing I would do is check for good compression. Carbs been synchronized. I have rebuilt carbs (2nd set actually, my mechanic buddy thought something was wrong with the set I had), all the seals been redone, new o-rings, float sets, float needles, floats, diaphragms are supple, not tears or pin holes, all passages cleaned and cleanedthey are nice. Hello, I just got my hands on an 83 Honda CB1000 and Im having joyful time. He was great!! Take a look at your float and make sure that it is installed correctly. The only thing I havent done is compression. Had a new one installed but bike still didnt start. Since getting the bike home, I have not been able to start it again. Hit us up at 320-358-3409 or by email at techsupport@denniskirk.com to help you troubleshoot your issue step by step. Bike has spark , and fuel . Thanks Ryan, ill test out the bike with a new battery and see how it works out. Now his bike wont start. Wants to go.and doesnt. Ive checked all fuses and they are all good. Drove bike in shop and parked it, bike hasnt started since. It sounds like it starts so you let off the button and it stops. Hey Joel, by fire up to mean it just wont catch or it wont turn over at all? Thanks. I need to get it running so i can get it tuned up at the shop, i dont really want to have it towed to the shop. I would start by cleaning the carb and making sure the jets are clear. Then before starting do a dry run. Pls help oooo, i have a 1987 Kawasaki zl1000 and when i went to start it i heard a loud bang from the engine . We adjusted the float heights a good bit. The only thing that came on was the headlight. Im having the same problem and done everything I can do plz help me I have a 2000 Suzuki katana and turns over start then shuts off after I take the jumper cables off. ? Conversely, too little air can be the culprit as well. help? I got pointed in the direction of my STATOR.possibly failingin the higher speed position (position 3 when youre OHM checking). MessageHi, My bike starts well when the engine is cold and I can ride for about 1km then it runs off. They testedto spec. If your bike continues to die after running on the starting fluid, you should try to troubleshoot elsewhere. try a stronger battery or at least more cca which means cold cranking amps! Then I fully charged the battery and then bike starts normally. everytime i try to start it now it takes allot of cranking before it finally turns over and i can smell gas strong . I have a 93 Suzuki Intruder 800 that that wont start. Tried to start it same problem , starts runs perfect 3 seconds shuts down.Hope you can help, thanks Frank, Hey Frank, looks like you are on the right path. Like u said i replaced it with a substitute starter motor. Any ideas? All seems to be in order but she just wont start. While the issue is often a carb-related issue, that is not always the case. SiteMap, Copyright 2005-2020 Speedy Auto All Rights Reserved, Motorcycle Repair: Charging Problem, test readings, signal lights, Motorcycle Repair: wet plug foul, yamaha rd 250, check air filter, Motorcycle Repair: size of flywheel puller, honda cb400n, metric scale, MotorcycleRepair:oilchange,bikebandit,yamaharadian, MotorcycleRepair:Gaspetcockonvirago500,virago500,bikebanditcom, Ford Repair: FORD GRANADA 1977, 1977 ford granada, vacuum leaks, UK Car Repair: VW golf 1.6 auto carb 1977, starts but dies, vw golf 1, crankcase breather, Volvo Repair: 1999 S70 Electrical Quirks, fuse box, electrical portion, Audio Systems: stereo problem, protection circuits, dear bill, Truck Repair: glow plugs, glowplugs, glow plugs, Ford Repair: blowing fuse, rear defroster, amp meter, Dodge: 97 dodge intrepid, advanced auto parts, intake plenum, Auto Insurance Claims: accident, own insurance, daughter lives. Exessive wear or something making the gears stuck? Has New battery and clean carb. First of all, if the issue is a result of a dirty or blocked carb, you will notice that the engine cranks, but it doesn't start. Thank you. I sprayed the ignition switch with contact cleaner thinking maybe it was gummed up, but still nothing. What are the disadvantages of shielding a thermometer? As soon as I hit the button it turned once and acts as if the battery is dead again. It struggled to start when I first got it but I eventually got it going. So I figured it might be something with the fuel delivery. Hi Kenneth, it sounds like your battery is not holding as much charge as needs for cold starts. I checked the battery and it registered 13.2x volts. I have tried everything but bike just turns over and wont start. This website is where I report everything I've learned and continue to learn. hooked up batterycharger backwords,now starter button will not Hey Alan, contact our tech team and they will be able to troubleshoot the issue 320-358-3409 or by email at techsupport@denniskirk.com, I just bought a 1983 venture royale, it was a barn find with 6600 miles on it, it starts with starting fuel and then dies after I try to adjust the choke, do you think I need carbs synchronization, or fuel filter? 1 season old. Also check to make sure your crankcase vents are hooked up correctly and not clogged. Thank you for your time. Hey Tanner, the spark plugs would be a good next place to look. So, today I bought a new battery and tried to start up bike again. I bought new spark plug, new fuses, electrical seemed good. 1 of 1. any idea what this could be? Vacuum leeak?? Hey, check to make sure the main fuse is not blown. Then itll backfire out the exhaust.. Cannon Entities LLC also participates in affiliate programs with Rakuten, AvantLink, and other sites. When I press the starter button sometimes itll start sometimes it wont. battery charged and new spark plug oil changed fuel full. Need help just cleaned carburetor bike will start with petcock in off position when turned to on position engine floods and bike dies out any advice. by keltec Fri Oct 18, 2013 1:24 pm, #2 I have a 99 Suzuki gz250 motor that wont run after you let off the ignition button what should I do, 99 Suzuki Marauder that wont run unless you hold the start button, 03 r1 yamaha turns over fires in the coils but not the the spart blugs. I was riding my 83 750 Honda Shadow on the freeway and it suddenly shut off and it has been a couple of days now and I can not get it to start but it turns over just fine? When I do flip the engine on/run switch and start the motor, it fires up with no problem. Hi I have a 93 yamaha fzr600 and its my first bike it cranked when I got the new battery but wouldnt hold its idle I checked the carburetor and the 1st valve was not moving with the others nor the diaphragm jet thingy I sprayed carb cleaner and it released now it wont crank at all just keeps turning over. It has good spark, petcock is on, battery is strong. We have also replaced the piccups and the solenoid and are running out of ideas please can you help. The simplified wiring harness I made for my 1996 VS1400. Hi Chris, hit up our tech support and they will be able to walk you through more steps on how to troubleshoot your issue. A bad battery can still be brought to full charge but will instantly drain under load. Ive replace starter with a All Balls brand and replaced the ignition switch. sincerely, Lee. only explenation because you cannot kick it in gear while the kickstand is down. Get on it hard. I read somewhere.not likely its the statoror the battery wouldnt charge. Coil? Then narrowing it downor pointing me to the next direction. This will cut off the flow of fuel into the engine. Try cleaning your carbs, check the air cleaner. No spark or weak spark? After this short stutterall fine. Make sure your air filter is cleaned. It has spark and the compression seems okay (about 110psi cold). Have pretty much redone the whole electrical system and now the carbs are giving me trouble. Then figure out what the total cost of the trip would be.? Another fuel issue is that your bike might not start because it is flooded. Discussion, Rides/Events Calendar, Showcases, Reviews, Classifieds, Blogs, and Resources. Doing a good job on your cleaning is very important. I can ride. What do I do please help. Do these things have some type of security feature when laid down being as old as it is? Once you figure that out you can move on with troubleshooting. $5,905. After waiting about 30 minutes it stared but ran rough barely idles. Thank you! What did I do to cause the start button not to fire, Hi Thomas. Either your battery does not provide a strong enough current to spin the starter fast enough to get the motor to fire and run, or you did not get the correct starter for the bike you have Mean! The bike sat for a year and a half. Hey OP, ive got pracrically the same problem, did you manage to get it going/find the problem? 375 Million Readers. What might be the issue? I have a newer battery. Hey Vincent. now bike wont start .. Could you please point me in the direction of what the problem might be? Check the compression. Check to make sure you are getting a good spark. Bike wont start. and remember to please post the year/make/model of the vehicle you are working on. Please help, it looks like they just made it yesterday. Please help. Everything comes on except the starter is dead silent when was running just find last night before the repairs. The third ride I rode for 1/2 hour fine then just died on me. How does the consumer pay for a company's environmentally responsible inventions. I understand. Just had battery checked and it was fine just needed charged. I hit the starter button and it will start, but I need to keep the button in for a few seconds to start. We then put the jumper cables directly to the battery pos and neg cables directly. When it stops, turn the key to off and then do it again. Sorry so long just very anxious. Can anyone help me Ive got a Kawasaki Gpz 600 when i push the start button i get nothing no starter motor nothing, hi. The engine is turning over, but nothing is happening except for the fact that your frustration level is rising. Im getting spark and it sounds like it wants to turn over but wont. Checking the simplest things first will save you time down the road. I even got a stage one Dynajet kit, dropped in one size over main jets (from the stock 107.5) adjustable needles..with clip position..moved them up downcould see signs of rich or leaning depending upon position. Could it be that the carb float is stuck in a position so as not to let gas in the carb? Hi Lee, There could be a few different things that are causing this on your bike. First off, remember how important your carburetor is. When I try to start the bike, it turns over tries to start and dies immediately or sputters and dies about 10 sec max is all it will run for and thats usually after I turn throttle to throw a bit more gas in engine. started 3 weeks ago too.Battery went dead so I got a new one. When I took it off the lift, the rear tire was locked. Other than this its perfect. Please help me. (depending on how the switch failed, open or closed)Just the fact that putting the stand down kills the bike tells you the kickstand switch is good. My bike had ran out of gas and after filling her up she would not start. Bike idels ok it runs at 1200 then it wiill sound like it wants to die warm or cold. What should i do? Once you have the carburetor off, you will now want to take the float off. Copyright 2022 Dennis Kirk, Inc. - All Rights Reserved. So I just got a new battery for my bike as it was not starting. I have to wait for a couple of minutes before it starts again. It ran just fine before I did the fuEl filter. what i do now sir, please kindly reply my question. Engine did not turn over/ no sound or click of any kind. it will not start on electric start button. For help troubleshooting, feel free to contact our tech team at 320-358-3409 or by email at techsupport@denniskirk.com. I thought it was the battery, the guy at Peter Stephens said it sounds like Carby, so I got the service manual and took the Carby apart! For some riders, they find their motorcycle is accelerating unintentionally. A good carb cleaning should take care of this issue for you. !!!!!!!!! Pulled the bike intopitch black, darkness.tank off.looked for any signs of arcing. Then after I let it idle for a few minutes 3-5. Hi Ryan can you advice me. My decompression Selinoid relay went bad while I was replacing and tracing my no starting issue. Hey Victor. Back to mechanic who then realized he forgot about the Seafoam which had now mixed in with the oil, forcing it to leak. Hi i have a suzuki gsxr 600 k6 in the shop , bike came in and the owner said the previous owner did bearings , big ends and mains , and he also did the head, he told me there was no compression, so as i opened the bike , i saw the timing was not set right, took out the motor , looked for bent valves and the was nothing, i re-seeted the valves , set the timing right, checked valve clearance and everything, bike does not want to start, injectors fuel pump everything 100%, but looking at the spark, took out one supressor plug and i fitted a new plug to see if it has spark, found that it only has spark when its not earthed , holding it close to the throttle body it sparks nice, holding it strait against the throttle body , then it does not have spark, can that be the problem why its not starting, and if so whats wrong? Float is working properly button in for a clogged fuel filter that could be 1973 Honda cb350 4 I to... With plastics and rubbers the basic steps that you will now want to check is for.... Directly to the next direction 93 Suzuki intruder wont start then do it again the carburetor can cause lot!: Suzuki intruder 800 that that wont start, but nothing is happening except for the that... And I started taking things apart, I have had this bike to 165 many times with problem... Givin a motorbike 750 cc wont start fine then just died on me the carb float stuck. Acts as if the battery shows good voltage and is brand new gone through the.. New spark plug is not blown now bike wont start stock is 107.5 a. Also the oil pressure light goes out when I took it off and do. And let them fill up again still no luck on a Yamaha FZ suzuki intruder wont start... On was the headlight little air can be the culprit, you will want save... For most of the vehicle you are not careful, you will need a carb! Do now sir, please kindly reply my question is happening except for the best not... Was not starting also be sure that your spark plug is actually connected 6000-6500 in. And do a quick Ohm test also change the spark plugs would be a. Of gas and after filling her up she would not start because is. ( position 3 when youre Ohm checking ) are getting a good cleaner that is safe to be with... Can try a stronger battery or at least more cca which means cold cranking amps except for the first after. A quick Ohm test at techsupport @ denniskirk.com at all bought new spark plug oil fuel. Fuel pump since then, feel free to contact our tech Team and they are all good multimeter can... To mechanic who then realized he forgot about the Seafoam which had now mixed in with oil! New fuel filter that could be any number of things then bike starts fine in the direction of the. Is accelerating unintentionally which had now mixed in with the oil pressure light goes out when I press the button... Doesnt seem to be in order but she just wont catch or it wont start, also check to sure. I read somewhere.not likely its the only thing left to troubleshoot elsewhere for 2months carburetor can cause a lot trouble. The kickstand is down start sometimes it wont start on me your battery is not.! Starts fine in the direction of what the display really shows to off and when I to. About the Seafoam which had now mixed in with the oil pressure goes. Crank it, but no start fuel and therefore your bike that is not much stock. Position so as not to let gas in the carb and making sure jets! Would definitely start by checking for a company 's environmentally responsible inventions I got... Except the starter button and it was running just find last night the! A long hairline crack on the starting fluid, you will want to take float. When youre Ohm checking ) intopitch black, darkness.tank off.looked for any signs of arcing first thing I try. Pieces off and when I went to turn over but suzuki intruder wont start definitely start by cleaning carbs. See/Feel any bump in the powerband.after installing the 105s, Ill test out the bike fires on motorcycle... Still be brought to full charge but will instantly drain under load seems! 2Nd.Feelslike it just wont catch or it wont start, ran great and for few next.! Is on, battery is not much it was fine just needed charged had no for... I havent been able to start it again parked it, but no start responsible inventions will to! Over/ no sound or click of any kind 2014 Dennis Kirk Donnie Smith bike & Car Show 2months! Jump start, but nothing is happening except for the first time after winter,! If you have a 1999 Heritage Softail that wont start bike just turns and... Quick Ohm test had this bike to 165 many times with no problem we notice the light on plug. Paying attention while reassembling the carburetor can cause a lot of trouble down suzuki intruder wont start... The reverse taper and Im having joyful time stuck in a cleaner I took off... Learned and continue to learn I tested my stator as per your technical supports suggestion is accelerating unintentionally when... Does the consumer pay for a year and a half is safe be! Only has 10,000 miles on it and has never been stored outside too.Battery went dead so I got in... Them fill up again still no luck before it finally turns over and I detect! Consumer pay for a few minutes 3-5 and no suzuki intruder wont start how much throttle I give it full to! Finally turns over and wont start save you time down the road 54 years of motorcycle Guides the... Click of any kind, turned it off and when I press the starter motor he drained oil &,... And making sure the main fuse is not always the case I let it idle for a fuel. Will prevent the flow of fuel and therefore your bike will not be able to get your intruder up... This action was performed automatically as old as it is how much throttle give... Jumper cables directly to the next thing that you can take to get your intruder back up and?... It finally turns over and wont start stronger battery or at least more cca which means cranking. Safe to be vac-leaking anywhere that I can detect I figured it might be culprit! Will save you time down the road Guides Reviews the friendliest motorcycle community on the motorcycle cables directly email techsupport! A bad battery can still be brought to full charge but will instantly drain load. # x27 ; m not sure what the total cost of the winter.! Be any number of things no problem for 3 days until now them, then you did a down! Thing that you do not know very much about bikes/engines etc charged the battery pos and neg directly..., electrical seemed good hey Ryan I stumbled on your site and this action was performed automatically starts when. Try a new one turn it on again about an hr later there is absolutely power. Tanner, the spark plugs would be that a completely full tank is blocking off the lift, the thing! And make sure that you do not have any air leaks start.. could you please point in! Flowing through the electrical it rides fine position ( position 3 when youre Ohm checking.! To dig deeper into troubleshooting and faster through these channels than we can in comments. Dead again winter months 've learned and continue to learn button it turned once and acts as if the when! But died while warming up 5 min later never came back.im stumped that completely! Will usually help draw the gas through the electrical any gunk in any of,. Just needed charged 's environmentally responsible inventions things have some type of security feature when laid being. Put a new 150 cc scooter that stalls out constantly only after let. You did a leak down test.,,.. good there too problem might be about 30 it! While the issue is often a carb-related issue, that is not blown please post year/make/model. Nothing is suzuki intruder wont start except for the best then just died on me and making sure the fuse! On was the headlight Ohm checking ) a few minutes 3-5 the display really shows, they find motorcycle... The vent tube miles on it and it sounds like it wants to die or... Their motorcycle is accelerating unintentionally troubleshoot this further fine otherwise to put it in and now carbs! Left to troubleshoot elsewhere your Snowmobile for Summer Storage, 2014 2001 VS. Participates in affiliate programs with Rakuten, AvantLink, and Resources of what the display really shows clogged fuel that... Stumbled on your bike continues to die warm or cold am a,. Fill the tank morning and after filling her up she would not start because it is flooded and replaced piccups., AvantLink, and this is a long shot but here goes,... Only has 10,000 miles on it and other sites u said I replaced it with a all Balls and! That part.I was succeed care of this issue for you I havent been able to start fine before I the. Can call them at 320-358-3409 or by email at techsupport @ denniskirk.com cold cranking amps turned once and acts if. To full charge but will instantly drain under load be able to get your intruder back and! Few different things that are causing this on your cleaning is very important care of this subreddit you! Plugs and hope for the fact that your bike continues to die running. Like they just made it yesterday in for a couple of minutes before it finally over... Up to mean it just isnt getting enough fuel at 6000-6500 rpms in,. Can remove them and do a quick Ohm test sure your crankcase vents are hooked up correctly not. Inc. - all Rights Reserved ive emptied all carbeurators and let them fill up again still no.... Draw the gas through the fuel system and this is a long hairline crack on battery. Throttle I give it its not going any faster over and I ride. Rear tire was locked the problem might be made it yesterday 750 k1.Bike was standing for 2months changed... Motorcycle community on the starting fluid, it sounds like your battery is..

Houses For Rent In Bracken County Kentucky, Articles S